SciCan HYDRIM L110w Spécifications

www.scican.com• Service Guide• Manuel maintenance• Wartungsanleitung• Manuale di manutenzioneHYDRIM L110wd/HYDRIM L110w Service Guide 96-108019 Rev 3.

Page 9HYDRIM L110w/wd Service GuideDimensions:Height (free-standing) 850 mm / 33.5" Height (built-in) 810 mm / 32" Width 600 mm / 23.75"

Page 10HYDRIM L110w/wd Service Guide• Always turn the unit OFF before adding softener salt or solutions. Beforeperforming routine maintenance or serv

Page 11HYDRIM L110w/wd Service Guide1.4 Hardware SpecificationsThis unit contains the following types of hardware:• Phillips pan head self-tapping met

Page 12HYDRIM L110w/wd Service Guide2. Installation2.1 Suggested Installation ConfigurationsBoth the Hydrim L110wd and Hydrim L110w units should only

Page 13HYDRIM L110w/wd Service Guide2. Installation2.3 Water Softener The Hydrim has an integrated water softening system and is shipped with the soft

Page 14HYDRIM L110w/wd Service Guide2. InstallationIf you have set the water softener to any setting above 0, the SALT indicator flashes whenyou need

Page 15HYDRIM L110w/wd Service Guide2. Installation2.6 Setup and Installation Tips1 The Hydrim L110wd instrument washer-disinfector functions properly

Page 16HYDRIM L110w/wd Service Guide2. Installation2.7 Optional Installation ConfigurationsOption 1. Free Standing600 mm / 23.75" 850 mm / 3

Page 17HYDRIM L110w/wd Service Guide2. Installation2.8 Controller Software FunctionsNOTE: When making modifications to the factory settings there can

Page 18HYDRIM L110w/wd Service Guide2. Installation7. Buttons 2 and 4 – “set dosing time”. The display shows “ch”, by pressing button 4 theuser can

1. Introduction . . . . . . . . . . . . . . . . . . . . . . 51.1 Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51.2

Page 19HYDRIM L110w/wd Service Guide3. Routine MaintenanceThese steps should be performed prior to inspecting the unit.3.1 FiltersInspect the coarse a

Page 20HYDRIM L110w/wd Service Guide3. Routine Maintenance3.4 Hoses1. Disconnect the cold water inlet hose, hot water inlet hose, and drain hose from

Page 21HYDRIM L110w/wd Service Guide4. Schematics4.1 Hydraulic Schematic – Hydrim L110wdDDrryyeerr Drye r Drain pumpCirculating pumpCirculating

Page 22HYDRIM L110w/wd Service Guide4. Schematics4.1 Hydraulic Schematic – Hydrim L110wLevel switchDryer Drain pumpCirculating pumpPChamber fullSalt

Page 23HYDRIM L110w/wd Service Guide4. Schematics4.2 ElectricalHydrim L110wd / Hydrim L110wBOSCH 1(Master)8765 43211212122167543 12X4 X6 X2 X7 X1 X57X

Page 24HYDRIM L110w/wd Service Guide5. Troubleshooting5.1 Primary Assessment1. Check the water connections both on the back of the unit and from the

Fault # Fault Result Detected by Subassembly5.4 Fault CodesPage 25HYDRIM L110w/wd Service Guide5. TroubleshootingE1E2E3E5E8Water heating failureFilli

Page 26HYDRIM L110w/wd Service Guide5. Troubleshooting5.5 Hydraulic OverviewShower topUpper wash armLower washarmPotHeat exchangeOpen air channelOver

Page 27HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the UnitWhen the various covers are removed from the unit:• Hazardous voltages ar

Page 28HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit6.4 Removing the Kick Plate1. Remove the screws on both ends of the kick

Page 2HYDRIM L110w/wd Service GuideSommaire1. Introduction . . . . . . . . . . . . . . . . . . . . . 381.1 Généralités . . . . . . . . . . . . . .

Page 29HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit6.9 Removing the Dryer 1. Remove top cover. (see section 6.3)2. Remove t

Page 30HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit6.10.1 Removing the On / Off Switch1. Remove the control panel fascia. (

Page 31HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit6.12 Removing Wash Tank1. Follow the directions for removing the followin

Page 32HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit8. Remove the four screws holding the door hinges together, andremove the

Page 33HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit6.13 Removing Drain Pump1. Remove the wash tank. (see section 6.12)2. Di

Page 34HYDRIM L110w/wd Service Guide6. Taking Apart and Reassembling the Unit6.16 Removing the Hot and Cold Inlet Valves1. Remove wires connected to t

Page 35HYDRIM L110w/wd Service Guide1. Switch 13488.00 flow heater2. O-ring 16939.00 temperature switch3. Box power-in 13454.004. Power switch 13459.0

Page 36HYDRIM L110w/wd Service Guide43. Left Door hinge lever 13623.00 door lever, left44. Right door hinge lever 13623.01 door lever, right45. Pipe 1

Page 37HYDRIM L110w/wd Service Guide7. PartsDescription Part Number Note89. Plate ring seal 21406.00 seal90. O-ring 21527.01 manifold91. Spare hose 21

Copyright 2005 SciCan. Alle Rechte vorbehalten.HYDRIM ist ein eingetragenes Warenzeichen von SciCan, Division ofLux and Zwingenberger.Page 3HYDRIM L1

Page 4HYDRIM L110w/wd Service GuideIndice1. Introduzione . . . . . . . . . . . . . . . . . . . . .1061.1 Sommario . . . . . . . . . . . . . . . . .

Page 5HYDRIM L110w/wd Service GuideRinse and holdRegular washHeavy duty washRegular wash and dryHeavy duty wash and dryP2P3P4 P1P01.1 OverviewThis gui

Page 6HYDRIM L110w/wd Service GuideThe Hydrim L110wd and Hydrim L110w are designed to complement the STATIM family ofautoclaves by quickly and hygieni

Page 7HYDRIM L110w/wd Service GuideThe Hydrim L110w instrument washer:The program duration and consumption details are shown in the chart below:* Actu

Page 8HYDRIM L110w/wd Service Guide1. Introduction1.2 SpecificationsHydrim L110wd washer disinfector:Dimensions:Height (free-standing) 850 mm Height (